网站地图
重复激光脉冲作用下薄膜损伤演化规律研究
Accumulation effect of film damage under repetitive laser pulses
-
摘要: 为了深入研究重复激光脉冲的能量效应对光学薄膜的烧蚀机理，采用实验观测与热力学分析相结合的方法进行了研究。通过观察光学薄膜烧蚀形貌随入射激光脉冲数量增加发生改变的典型形貌特征，分析了激光与等离子体相互作用的热力学过程，得到了在激光重复脉冲作用下光学薄膜的损伤特性及其演化规律。结果表明，薄膜在重复脉冲作用下，其表面会变得粗糙，这会大大增加对激光的吸收效应，从而加速了薄膜的破坏，最终被完全去除而露出基底；同时，烧蚀物会在热膨胀作用下向激光作用区域外扩散，在激光烧蚀中心区域外进行沉积，而形成更大范围的污染。由于激光光强为高斯分布，重复脉冲作用的效应主要是对在光束中心区域的薄膜进行集中烧蚀，会不断增加烧蚀的损伤程度，而对烧蚀面积的增加效应极为有限。这一研究结果为重复激光脉冲对薄膜烧蚀机理的建立提供了参考。Abstract: In order to study the accumulation effect of film damage under repetitive laser pulses, experimental observations and thermodynamic analysis were carried out. The morphologies damaged by single and multiple laser pulses were observed under a 5000× microscope, then the thermodynamic process between the interaction of laser and plasma was analyzed. Finally the evolution rule of the film damage was found. Both of these two damaged morphologies can be explained by the thermodynamic interactions between laser and laser plasmas. The research results show that: the rough surface of thin film is induced by the laser pulses, which will absorb more laser energy than the beginning. The melt will be removed by the stronger ablation and will be accumulated outside of the laser working area. Since the laser energy is Gaussian distributed, the damaged of multiple laser pulses is centralized and the ablation is limited at the center of laser beam only. This result is a preference for study about film ablation under repetitive laser pulses.
-
Key words:
- laser technique /
- repetitive laser pulse /
- thin film damage /
- Gaussian beam /
- X-ray diffraction spectra
-
[1] NéAUPORT J, BLANCHOT N, ROUYER C, et al. Chromatism compensation of the PETAL multipetawatt high-energy laser[J].Applied Optics, 2007, 46(9):1568-15704. [2] HAYNAM C A, WEGNER P J, AUERBACH J M, et al. National ignition facility laser performance status[J].Applied Optics, 2007,46(16): 3276-3303. [3] ZHAO Y A, GAO W D, SHAO J D, et al. Roles of absorbing defects and structural defects in multilayer under single-shot and multi-shot laser radiation[J]. Applied Surface Science, 2004,227(1/4): 275-281. [4] ZHOU M, SHAO J D, FAN Zh X, et al. Effect of multiple wavelengths combination on laser-induced damage in multilayer mirrors[J]. Optics Express, 2009,17(22):20313-20320. [5] CARR C W, FEIT M D, RUBENCHIK A M, et al. Radiation produced by femtosecond laser-plasma interaction during dielectric breakdown [J]. Optics Letters, 2005,30(6): 661-663. [6] ZHAO Y, WANG T, ZHANG D, et al. Laser conditioning and multi-shot laser damage accumulation effects of HfO2/SiO2 antireflective coatings[J]. Applied Surfer Science, 2005, 245(1/4):335-339. [7] MATSUBARA K,FONS P,IWATA K,et al. Room-temperature deposition of Al-doped ZnO films by oxygen radical-assisted pulsed laser deposition [J]. Thin Solid Films, 2002,422(1/2):176-179. [8] ZHOU H M, YI D Q. Effect of rare earth doping on thermo-physical properties of lanthanum zirconate ceramic for thermal barrier coatings[J]. Journal of Rare Earths, 2008,26(6): 770-774. [9] LIU F, YU Z, CHEN S, et al. Vanadium oxide thin films prepared by reactive magnetron sputtering[J].Metal Materials and Engineering, 2008, 37(12):2221-2225 (in Chinese). [10] LI R. Study on laser damage properties of optical dielectric films. Xi'an: Xi'an Technological University, 2010:28-38(in Chinese). [11] ALLMEN M V.Laser-beam interactions with materials physical principles and applications[M]. Beijing:Science Press,1994:55-70(in Chinese). [12] EYYUBOGLU H T, BAYKAL Y. Average intensity and spreading of cosh-Gaussian laser beams in the turbulent atmosphere[J].Applied Optics, 2005,44(6):976- 983. [13] DAI G,LU J, WANG B, et al.Analysis and comparision of coating damage induced by laser at 1ms and 10ns pulse-widths[J].Laser Technology,2011,35(4): 477-480(in Chinese). -
点击查看大图
计量
- 文章访问数: 3165
- HTML全文浏览量: 670
- PDF下载量: 650
- 被引次数: 0
下载:
